Issue
Korean Journal of Chemical Engineering,
Vol.17, No.1, 1-11, 2000
Shape-Selective Alkylation of Biphenyl Catalyzed by H-Mordenites
Liquid phase alkylation of biphenyl was studied over large pore zeolites. Selective formation of the narrowest products, 4,4''-diisopropylbiphenyl (4,4''DIPB), occurred only HM among the zeolites with twelve-membered pore openings. These shape-selective catalyses are ascribed to steric restriction of transition state and to entrance of bulky substrates into the pores. The dealumination of HM enhanced catalytic activity and the selectivity of 4,4''-DIPB because of the decrease of coke-deposition, while the activity and the selectivity were low over HM with the low SiO2/AI2O3 ratio. Non-regioselective catalysis occurs on external acid sites because severe cokedeposition deactivates the acid sites inside the pores by blocking pore opening. The selectivity of DIPB isomers was changes with propylene pressure and/or with reaction temperature. 4,4''-DIPB yielded selectively under high propylene pressure(<0.3MPa) at 250℃, while the selectivity of 4,4''-DIPB decreased under such low propylene pressure as 0.2 MPa. Selective formation of 4,4''DIPB was observed at moderate temperature such as 250℃, whereas the decrease of the selectivity of 4,4''DIPB occurred at higher temperature as 300℃. However, 4,4''-DIPB was almost exclusively isomer in the encapsulated DIPB isomers inside the pores under every pressure and temperature. These decreases of the selectivity of 4,4''-DIPB are due to the isomerization of 4,4''-DIPB on the external acid sites. The deactivation of external acid sites of HM was examined to reduce non-regioselective alkylation and isomerization. External acid sites were deactivated by calcination after impregnation of cerium on HM without the decrease in pore radii. Selectivities of 4,4''-DIPB were improved even at high temperatures in the isopropylation of biphenyl because of the suppression of non-regioselective alkylation and isomerization at the external acid sites. The selectivity of 4.4''-diethylbiphenyl(4,4''-DIPB) in the ethylation of biphenyl was much lower than that in the isopropylation. Among the DIPB isomers, 4,4''-DIPB has the higher reactivity for the ethylation to polyethylbiphenyls inside the pores, whereas the isopropylation of 4,4''-DIPB was negligibly low inside the pores. These differences are ascribed to the difference in steric restriction at the transition state compound of substrate, alkylating agent, and acid sites inside the pores.
[References]
  1. Anastas PT, Williamson TC, "Green Chemistry. Frontiers in Benign Chemical Synthesis and Processes," Oxford University Press, Oxford, 1998
  2. Csicsery SM, Zeolites, 4, 202, 1984
  3. Venuto PB, Microporous Mater., 2, 297, 1994
  4. Sugi Y, Kubota Y, "Shape-selective Catalysis of Zeolite in the Alkylation of Aromatics," in Catalysis, Spivey, J.J. (ed.), Specialist Periodical Report, Royal Soc. Chem., London, Chapter 3, 13, 55, 1997
  5. Kaeding WW, Chu C, Young LB, Weinstein B, Butter J, J. Catal., 67, 159, 1981
  6. Namba S, Kim JH, Yashima T, Stud. Surf. Sci. Catal., 83, 279 (1994) and their earlier papers cited in
  7. Young LB, Butter SA, Kaeding WW, J. Catal., 76, 418, 1982
  8. Karge HG, Laderbeck J, Sarbak Z, Hatada K, Zeolites, 2, 94, 1982
  9. Polym. Soc. Japan (ed.), in "High Performance Polynuclear Aromatics Materials," Maruzen, Tokyo, 1990
  10. Matsuzaki T, Sugi Y, Hanaoka T, Takeuchi K, Arakawa H, Tokoro T, Takeuchi G, Chem. Express, 4, 413, 1989
  11. Sugi Y, Matsuzaki T, Hanaoka T, Takeuchi K, Tokoro T, Takeuchi G, Stud. Surf. Sci. Catal., 60, 303, 1991
  12. Sugi Y, Matsuzaki T, Hanaoka T, Kubota Y, Kim JH, Tu X, Matsumoto M, Stud. Surf. Sci. Catal., 90, 397, 1994
  13. Hanaoka T, Nakajima K, Sugi Y, Matsuzaki T, Kubota Y, Tawada S, Kunimori K, Igarashi A, Catal. Lett., 50(3-4), 149, 1998
  14. Tu X, Matsumoto M, Matsuzaki T, Hanaoka T, Kubota Y, Sugi Y, Catal. Lett., 21, 71, 1993
  15. Sugi Y, Tu X, Matsuzaki T, Hanaoka T, Kubota Y, Kim JH, Matsumoto M, Nakajima K, Igarashi A, Catal. Today, 31(1-2), 3, 1996
  16. Tawada S, Kubota Y, Sugi Y, Hanaoka T, Matsuzaki T, Catal. Lett., 57(4), 217, 1999
  17. Sugi Y, Tawada S, Sugimura T, Kubota Y, Hanaoka T, Matsuzaki T, Nakajima K, Kunimori K, Appl. Catal. A: Gen., 189(2), 251, 1999
  18. Sugi Y, Matsuzaki T, Hanaoka T, Kubota Y, Kim JH, Tu X, Matsumoto M, Sekiyu Gakkaishi, 37, 557, 1994
  19. Takeuchi G, Okazaki H, Kito T, Sugi Y, Matsuzaki T, Sekiyu Gakkaishi, 34, 242, 1991
  20. Sugi Y, Tawada S, Sugimura T, Kubota Y, manuscript in preparation
  21. Nakajima K, Tawada S, Sugi Y, Kubota Y, Hanaoka T, Matsuzaki T, Kunimori K, Chem. Lett., 215, 1999
  22. Matsumoto M, Tu X, Sugi Y, Matsuzaki T, Hanaoka T, Kubota Y, Kim JH, Nakajima K, Igarashi A, Kunimori K, Stud. Surf. Sci. Catal., 105, 1317, 1997
  23. Nakajima K, Hanaoka T, Sugi Y, Matsuzaki T, Kubota Y, Igarashi A, Kunimori K, "Influences of Bulkiness of Reagents in the Alkylation of Biphenyl over H-Mordenite," in "Shape Selective Catalysis-Chemicals Synthesis and Hydrocarbon Processing," ACS Symposium Series 738, Song, C., Garces, J.M. and Sugi, Y. (eds), Am. Chem. Soc., Chapter 19, 260, 1999
  24. Lee GS, Maj JJ, Rocke SC, Garces JM, Catal. Lett., 2, 243, 1989
  25. Taniguchi T, Tanaka M, Takahata K, Sakamoto N, Takai T, Kurano Y, Ishibushi M, "Process for Producing Alkyl-group-substituted Aromatic Hydrocarbons," PCT Int., Appl., WO 88 03523 (assigned to Mitsui Petrochem. Ind. Ltd.)
  26. Sakamoto N, Takai T, Taniguchi K, Takahata K, "Process for the Catalytic Preparation of p,p'-Dialkylbiphenyls," Jpn. Tokkyo Kokai Koho, 88-122635 (assigned to Mitsui Petrochem. Ind. Ltd)
  27. Fellmann J, in Catalytica Highlights, 17(#1), 1, 1991
  28. Matsuda T, Kikuchi E, Stud. Surf. Sci. Catal., 83, 295, 1994
  29. Matsuda T, Urata T, Saito U, Kikuchi E, Appl. Catal. A: Gen., 131(2), 215, 1995
  30. Matsuda T, Kimura T, Herawati E, Kobayashi C, Kikuchi E, Appl. Catal. A: Gen., 136(1), 19, 1996
  31. Kim JH, Matsuzaki T, Hanaoka T, Kubota Y, Sugi Y, Matsumoto M, Tu X, Microporous Mater., 5, 113, 1995
  32. Sugi Y, Kim JH, Matsuzaki T, Hanaoka T, Kubota Y, Tu X, Matsumoto M, Stud. Surf. Sci. Catal., 84, 1837, 1994
  33. Kim JH, Sugi Y, Matsuzaki T, Hanaoka T, Kubota Y, Tu X, Matsumoto M, Kato A, Seo G, Pak C, Appl. Catal. A: Gen., 131(1), 15, 1995
  34. Katayama A, Toba M, Takeuchi G, Mizukami F, Niwa S, Mitamura S, J. Chem. Soc.-Chem. Commun., 39, 1991
  35. Song C, Schmitz AD, Sekiyu Gakkaishi, 42, 275 (1999), and their previous papers cited in
  36. Chu SJ, Chen YW, Appl. Catal. A: Gen., 123(1), 51, 1995
  37. Derouane EG, Gabelica Z, J. Catal., 65, 486, 1980
  38. Meier WM, Olson DH, Baerlocher CH, "Atlas of Zeolite Structure Types," 4th revised edition, Elsevier, Amsterdam, 1996
  39. Dejaifve P, Auroux A, Gravelle PC, Vedrine JC, Gabelica Z, Derouane EG, J. Catal., 70, 123, 1981
  40. Guisnet M, Magnoux P, Appl. Catal., 54, 1, 1989
  41. Bhatia S, Beltramini J, Do DD, Catal. Rev.-Sci. Eng., 31, 431, 1989
  42. Karge HG, Weitkamp J, Chem. Ind. Technol., 58, 946, 1986
  43. Meyers L, Fleisch TH, Ray GJ, Miller JT, Hall JB, J. Catal., 110, 82, 1988
  44. Sawa M, Niwa M, Murakami Y, Appl. Catal., 53, 169, 1989
  45. Itabashi K, Fukushima T, Igawa K, Zeolites, 6, 30, 1986