Korean Journal of Chemical Engineering, Vol.29, No.5, 595-600, 2012
Conditional monitoring of moisture content in a fluidized bed dryer by the acoustic emission signature
Wetted rice particles were dried in a fluidized bed and the corresponding passive acoustic emissions signals (AES) were recorded at a given frequency to study the drying phenomena and bed hydrodynamic changes as well. The results show that the end time of the constant rate zone and the end of the falling rate can be determined from the variation of standard deviation and kurtosis of AES, respectively. Frequency domain analysis was also used to quantify the moisture content of solids. For this end, the original signal was decomposed into ten sub-signals, and it was found that the energy of the 4th sub-signal can be correlated with the moisture content. The results show that the acoustic emission measurement is applicable as a practical method for on-line condition monitoring of drying process in fluidized bed dryers.
[References]
Son SY, Lee DH, Han GY, Kim DJ, Sim SJ, Kim SD, Korean J. Chem. Eng. , 22 (2), 315, 2005
Choung YH, Cho KC, Choi WJ, Kim SG, Han YS, Oh KJ, Korean J. Chem. Eng. , 24 (4), 660, 2007
Lu WM, Ju SP, Tung KL, Lu YC, Korean J. Chem. Eng. , 16 (6), 810, 1999
Schouten JC, van den Bleek CM, AIChE J. , 44 (1), 48, 1998
Sasic S, Leckner B, Johnsson F, Prog. Energy Combust. , 33 , 453, 2007
Finney CEA, Daw CS, Halow JS, Kona Powder Part. J. , 16 , 125, 1997
Tsujimoto H, Yokoyama T, Huang CC, Sekiguchi I, Powder Technol. , 113 , 88, 1999
Briongos JV, Aragon JM, Palancar MC, Powder Technol. , 162 (2), 145, 2006
Salehi-Nik N, Sotudeh-Gharebagh R, Mostoufi N, Zarghami R, Mahjoob MJ, Int. J. Multiphase Flow. , 35 , 1011, 2009
Abbasi M, Sotudeh-Gharebagh R, Mostoufi N, Mahjoob MJ, Powder Technol. , 196 (3), 278, 2009
Abbasi A, Sotudeh-Gharebagh R, Mostoufi N, Zarghami R, Mahjoob MJ, AIChE J. , 56 (3), 597, 2010
Azizpour H, Sotudeh-Gharebagh R, Zarghami R, Abbasi M, Mostoufi N, Mahjoob MJ, Int. J. Multiphase Flow. , 37 , 788, 2011
Mudde RF, Bruneau PRP, van der Hagen THJJ, Ind. Eng. Chem. Res. , 44 (16), 6181, 2005
Chen A, Bi HT, Grace JR, Powder Technol. , 177 (3), 113, 2007
Demirbas B, Nijenhuis J, Yurteri CU, van Ommen JR, Can. J. Chem. Eng. , 86 (3), 493, 2008
Boyd JWR, Varley J, Chem. Eng. Sci. , 56 (5), 1749, 2001
Friesen TL, Bruswitz GH, Lowery RL, J. Agr. Eng. Res. , 39 , 49, 1988
Vervloet D, Nijenhuis J, van Ommen JR, Powder Technol. , 197 , 36, 2009
Zarghami R, Mostoufi N, Sotudeh-Gharebagh R, Chaouki J, Cheng L, Mewes D,Nonlinear dynamic characteristic of bubbling fluidization, Advances in Multiphase Flow and Heat Transfer. Bentham Science Publishers Ltd., 3 , 400, 2010
Van der Schaaf J, Schouten JC, Johnsson F, van den Bleek CM, Int. J. Multiphase Flow. , 28 , 865, 2002
Wormsbecker M, Pugsley T, Tanfara H, Chem. Eng. Sci. , 64 (8), 1739, 2009
Johnsson F, Zijerveld RC, Schouten JC, van den Bleek CM, Leckner B, Int. J. Multiph. Flow , 26 (4), 663, 2000
Mallat S, IEEE T. Pattern Anal. , 11 , 674, 1989
Chaplin G, Pugsley T, Winters C, Powder Technol. , 142 (2-3), 110, 2004
Oppenheim AV, Willsky AS, Nawab SH,, Signal and Systems, Prentice-Hall, 1997
Choi KB, Park SI, Park YS, Sung SW, Lee DH, Korean J. Chem. Eng. , 19 (6), 1106, 2002
Karimi K, Sotudeh-Gharebagh R, Zarghami R, Mostoufi N, Dry. Technol. , 29 , 1697, 2011
Zarghami R, Conditional monitoring of fluidization quality in fluidized beds, Ph.D. Dissertation, University of Tehran, Tehran, Iran, 2009
이전 논문 다음 논문
Result Search