아민 흡수 공정에서 아민은 O2 및 고온에 의해 비가역반응을 일으키며, 이러한 현상을 열화반응이라 한다. 열화반응은 아민의 가치를 떨어뜨릴 뿐만 아니라 부식, fouling과 같은 문제를 일으킨다. 따라서, 본 연구에서는 여러가지 화학흡수제(MEA; monoethanolamine, AMP; 2-amino-2-methyl-propanol, DAM; 1,8-diamino-p-menthane)를 이용하여 i) 50, 120 ℃에서의 흡수평형, ii) CO2 및 CO2/O2 계에서 흡수제의 열화에 따른 농도변화 및 초기열화속도상수, iii) 산소(O2)에 의한 열화 영향을 살펴보았다. DAM은 흡수영역에서 MEA와 AMP에 비해 400~270% 높은 흡수평형부하를 보이며, MEA나 AMP에 비해 흡수/재생영역에서 흡수평형부하가 커 흡수능이 우수하였다. CO2계에서 DAM의 초기열화속도상수는 2.254×10^(-4) cycle^(-1)로 MEA와 AMP의 2.761×10^(-4) cycle^(-1), 2.416×10^(-4) cycle^(-1)에 비해 작아 열화가 늦게 진행되며, O2 주입시 초기열화속도상수는 1.3배 증가하여 2배 증가한 MEA보다 열화 영향이 적었다. 이러한, 일련의 열화반응은 GC chromatogram에서 새로운 peak의 생성과 FT-IR spectrum 분석을 통하여 확인할 수 있었다.
Amine can undergo irreversible reactions by O2 and high temperature in amine scrubbing process and these phenomena are called “degradation”. Degradation causes not only a loss of valuable amine, but also operational problems such as foaming, corrosion and fouling. In this study, using various chemical absorbents(MEA; monoethanolamine, AMP; 2-amino-2-methyl-1-propanol, DAM; 1,8-diamino-p-menthane), we examined the following variable. i) loading ratio of CO2 at 50 ℃ and 120 ℃, ii) concentration variation and initial degradation rate constant of absorbent in CO2 and CO2/O2 system, and iii) effect of degradation by O2. The CO2 loading of 20 wt% DAM was 400% and 270% higher than that of 20 wt% MEA and AMP at 50, respectively and was the largest the difference of CO2 loading between absorption (50 ℃) and regeneration (120℃) condition. The initial degradation rate constant of 20 wt% DAM was 2.254×10^(-4) cycle^(-1) which was slower than that of MEA (2.761×10^(-4) cycle^(-1) and AMP (2.416×10^(-4) cycle^(-1) in CO2 system. Also, it was increased 30% by O2 that effects on the degradation by O2 was less than 100% increased. these degradation reactions was able to identify by formation of new peak in GC and FT-IR spectrum analysis.
Morimoto S, Taki K, Maruyama T, “Current Review of CO2 Separation and Recovery Technologies,” Oct. 5, RITE, 2002
Kim JH, Lee JH, Jang KR, Shim JG, J. Kor. Soc. Environ. Eng., “Degradation Characteristics of Carbon Dioxide Absorbents with Different Chemical Structures”, 31, 883, 2009
Kennard ML, Meisen A, Ind. Eng. Chem. Fundam., “Mechanisms and Kinetics of DEA Degradation", 24, 129, 1985
Chakma A, Meisen A, J. Chromatogr., “Identification of Methyldiethanolamine Degradation Products by Gas Chromatography and Gas Chromatography-mass Spectrometry,”, 457, 297, 1988
Choi WJ, Lee JJ, Cho KC, Oh KJ, J. Kor. Soc. Environ. Eng., “Degradation Characteristics of Aqueous AMP Solution Containing Addit in Separation of CO2/H2S”, 27, 280, 2005
Xu S, Wang YW, Otto FD, Mather AE, Chem. Eng. Process., “Representation Of Equilibrium Solubility Properties Of Co2 With aqueous solutions of 2-amino-2-methyl-1-propano", 31, 7, 1992
Caplow M, J. Am. Chem. Soc., “Kinetics of Carbamate Formation and Breakdown,”, 90, 6795, 1968
Polderman LD, Steele AB, Oil Gas J., “Why Diethanolamine Breakdown in Gas Treating Service", 54, 206, 1956
Kennard, ML, “Degradation of Diethanolamine Solutions,” Ph.D. Thesis, Univ. of British Columbia, 1983